Study on the strata displacement law of overlapping shield tunnels with different overlapping angles

Yang Zhiyong; Niu Yuzhe; Ding Yaowen; Qi Weiqiang; An Hongbin; Jiang Yusheng

doi:10.19606/j.cnki.jmst.2023.04.008

Volume 8 Issue 4

Aug. 2023

Turn off MathJax

Article Contents

Article Navigation > Journal of Mining Science and Technology > 2023 > 8(4): 519-528

Yang Zhiyong, Niu Yuzhe, Ding Yaowen, Qi Weiqiang, An Hongbin, Jiang Yusheng. Study on the strata displacement law of overlapping shield tunnels with different overlapping angles[J]. Journal of Mining Science and Technology, 2023, 8(4): 519-528. doi: 10.19606/j.cnki.jmst.2023.04.008

Citation:

PDF( 14672 KB)

Study on the strata displacement law of overlapping shield tunnels with different overlapping angles

doi: 10.19606/j.cnki.jmst.2023.04.008

1.
Schoot of Mechanics and Civil Engineering, China University of Mining and Technology-Beijing, Beijing 100083, China
2.
The 2nd Engineering Co., Ltd.of China Railway 12th Bureau Group., Taiyuan Shanxi 030032, China

Received Date: 2022-11-07
Rev Recd Date: 2022-12-15
Publish Date: 2023-08-31

Abstract

Abstract

Based on the overlapping tunnel of Tel Aviv Red Line Light Rail Project in Israel, this study established a three-dimensional numerical model by using Rhino6 and FLAC^3D software on the basis of analysis of on-site monitoring data, to investigate the ground settlement and stratum displacement laws of shield overlapping tunnel at different overlapping angles.Results show that when the two tunnels gradually transit from horizontal to overlapping state, with the increase of overlapping angle of the two tunnels, the accumulated settlement at the measuring points in the middle of the two tunnels increases, but the accumulated settlement is not only affected by overlapping angle, but also closely related to the stratum traversing situation.Under the stratum condition of the project, when the overlapping angle is 60°, the accumulated surface settlement reaches the maximum because both tunnels pass through the loose reservoir K1 stratum.When the overlapping angle of the rear-built tunnel is less than 45° after excavation, the width of the settlement trough increases.When the overlapping angle is larger than 45° and smaller than 60°, the width of the settlement trough remains unchanged.The width of settlement trough decreases when the overlapping angle is larger than 60°.When the overlapping angle reaches 90°, the settlement trough is symmetrical on both sides.After excavation of tunnels on both sides, when the overlapping angle of the tunnels reaches 75°, the strata on both sides change the direction of movement.This research offer reference for the design and construction of overlapping tunnels.
- overlapping tunnels,
- EPB shield,
- overlapping angles,
- numerical simulation,
- stratum displacement

FullText(HTML)

References(26)

References

[1]	Do N A, Dias D, Oreste P. Three-dimensional numerical simulation of mechanized twin stacked tunnels in soft ground[J]. Journal of Zhejiang University SCIENCE A, 2014, 15(11): 896-913. doi: 10.1631/jzus.A1400117
[2]	Dias D, Kastner R. Movements caused by the excavation of tunnels using face pressurized shields-analysis of monitoring and numerical modeling results[J]. Engineering Geology, 2013, 152(1): 17-25. doi: 10.1016/j.enggeo.2012.10.002
[3]	刘维, 唐晓武, 甘鹏路, 等. 富水地层中重叠隧道施工引起土体变形研究[J]. 岩土工程学报, 2013, 35(6): 1055-1061. https://www.cnki.com.cn/Article/CJFDTOTAL-YTGC201306011.htm Liu Wei, Tang Xiaowu, Gan Penglu, et al. Soil deformation induced by overlapping tunneling in water-bearing strata[J]. Chinese Journal of Geotechnical Engineering, 2013, 35(6): 1055-1061. https://www.cnki.com.cn/Article/CJFDTOTAL-YTGC201306011.htm
[4]	Yang Z Y, Ding Y W, Jiang Y S, et al. Study of the construction sequence of overlapping tunnels by the shield tunneling method: a case study of the longest overlapping tunnel in China[J]. Advances in Civil Engineering, 2020, 2020: 1-9.
[5]	Zheng G, Zhang T Q, Diao Y. Mechanism and countermeasures of preceding tunnel distortion induced by succeeding EPBS tunnelling in close proximity[J]. Computers and Geotechnics, 2015, 66: 53-65. doi: 10.1016/j.compgeo.2015.01.008
[6]	李婕, 张琪, 张稳军. 不同地质条件下盾构隧道受力变形特性研究[J]. 土木工程学报, 2019, 52(S1): 69-77. https://www.cnki.com.cn/Article/CJFDTOTAL-TMGC2019S1010.htm Li Jie, Zhang Qi, Zhang Wenjun. Research on inner force and deformation characteristics of shield tunnel under different geological conditions[J]. China Civil Engineering Journal, 2019, 52(S1): 69-77. https://www.cnki.com.cn/Article/CJFDTOTAL-TMGC2019S1010.htm
[7]	Naseem A, Schotte K, De Pauw B, et al. Ground settlements due to construction of triplet tunnels with different construction arrangements[J]. Advances in Civil Engineering, 2019, 2019: 1-18.
[8]	Chakeri H, Hasanpour R, Ali Hindistan M, et al. Analysis of interaction between tunnels in soft ground by 3D numerical modeling[J]. Bulletin of Engineering Geology and the Environment, 2011, 70(3): 439-448. doi: 10.1007/s10064-010-0333-8
[9]	Liu X, Fang Q, Zhang D L, et al. Behaviour of existing tunnel due to new tunnel construction below[J]. Computers and Geotechnics, 2019, 110: 71-81. doi: 10.1016/j.compgeo.2019.02.013
[10]	Yan Q X, Song L Y, Chen H, et al. Dynamic response of segment lining of overlapped shield tunnels under train-induced vibration loads[J]. Arabian Journal for Science and Engineering, 2018, 43(10): 5439-5455. doi: 10.1007/s13369-018-3147-9
[11]	Gharehdash S, Barzegar M. Numerical modeling of the dynamic behaviour of tunnel lining in shield tunneling[J]. KSCE Journal of Civil Engineering, 2015, 19(6): 1626-1636. doi: 10.1007/s12205-015-0406-0
[12]	林刚. 地铁重叠隧道施工顺序研究[J]. 现代隧道技术, 2006, 43(6): 23-28. https://www.cnki.com.cn/Article/CJFDTOTAL-XDSD200606004.htm Lin Gang. Study on the construction sequence of overlapped metro tunnels[J]. Modern Tunnelling Technology, 2006, 43(6): 23-28. https://www.cnki.com.cn/Article/CJFDTOTAL-XDSD200606004.htm
[13]	孙钧, 刘洪洲. 交叠隧道盾构法施工土体变形的三维数值模拟[J]. 同济大学学报: 自然科学版, 2002, 30(4): 379-385. https://www.cnki.com.cn/Article/CJFDTOTAL-TJDZ200204000.htm Sun Jun, Liu Hongzhou. 3-D numerical simulation of ground surface settlement under overlapped shield tunneling[J]. Journal of Tongji University, 2002, 30(4): 379-385. https://www.cnki.com.cn/Article/CJFDTOTAL-TJDZ200204000.htm
[14]	陈先国, 王显军. 近距离重叠隧道的二维和三维有限元分析[J]. 西南交通大学学报, 2003, 38(6): 643-646, 702. https://www.cnki.com.cn/Article/CJFDTOTAL-XNJT200306007.htm Chen Xianguo, Wang Xianjun. 2D and 3D finite element analyses of overlapping tunnels[J]. Journal of Southwest Jiaotong University, 2003, 38(6): 643-646, 702. https://www.cnki.com.cn/Article/CJFDTOTAL-XNJT200306007.htm
[15]	Fang K D, Yang Z Y, Jiang Y S, et al. Surface subsidence characteristics of fully overlapping tunnels constructed using tunnel boring machine in a clay stratum[J]. Computers and Geotechnics, 2020, 125: 103679. doi: 10.1016/j.compgeo.2020.103679
[16]	章慧健, 仇文革, 冯冀蒙, 等. 近距离重叠隧道盾构施工的纵向效应及对策研究[J]. 岩土力学, 2010, 31(11): 3569-3573. https://www.cnki.com.cn/Article/CJFDTOTAL-YTLX201011036.htm Zhang Huijian, Qiu Wenge, Feng Jimeng, et al. Study of longitudinal mechanical behavior and countermeasure for neighborhood overlapped shield tunneling[J]. Rock and Soil Mechanics, 2010, 31(11): 3569-3573. https://www.cnki.com.cn/Article/CJFDTOTAL-YTLX201011036.htm
[17]	谢雄耀, 牛俊涛, 杨国伟, 等. 重叠隧道盾构施工对先建隧道影响模型试验研究[J]. 岩石力学与工程学报, 2013, 32(10): 2061-2069. https://www.cnki.com.cn/Article/CJFDTOTAL-YSLX201310016.htm Xie Xiongyao, Niu Juntao, Yang Guowei, et al. Model test for effects of construction of shield tunnelling in overlapping tunnels on existing tunnel[J]. Chinese Journal of Rock Mechanics and Engineering, 2013, 32(10): 2061-2069. https://www.cnki.com.cn/Article/CJFDTOTAL-YSLX201310016.htm
[18]	Choi J I, Lee S W. Influence of existing tunnel on mechanical behavior of new tunnel[J]. KSCE Journal of Civil Engineering, 2010, 14(5): 773-783. doi: 10.1007/s12205-010-1013-8
[19]	Yang J S, Liu B C, Wang M C. Modeling of tunneling-induced ground surface movements using stochastic medium theory[J]. Tunnelling and Underground Space Technology, 2004, 19(2): 113-123. doi: 10.1016/j.tust.2003.07.002
[20]	张治国, 张成平, 奚晓广. 双线隧道不同布置方式下相互作用影响的地层位移解析[J]. 岩土工程学报, 2019, 41(2): 262-271. https://www.cnki.com.cn/Article/CJFDTOTAL-YTGC201902004.htm Zhang Zhiguo, Zhang Chengping, Xi Xiaoguang. Closed solutions to soil displacements induced by twin-tunnel excavation under different layout patterns[J]. Chinese Journal of Geotechnical Engineering, 2019, 41(2): 262-271. https://www.cnki.com.cn/Article/CJFDTOTAL-YTGC201902004.htm
[21]	龚建伍, 夏才初, 雷学文. 浅埋小净距隧道围岩压力计算与监测分析[J]. 岩石力学与工程学报, 2010, 29(S2): 4139-4145. https://www.cnki.com.cn/Article/CJFDTOTAL-YSLX2010S2099.htm Gong Jianwu, Xia Caichu, Lei Xuewen. Analysis of field measurement and theoretical calculation on rock pressure in shallow-buried twin tunnels with small spacing[J]. Chinese Journal of Rock Mechanics and Engineering, 2010, 29(S2): 4139-4145. https://www.cnki.com.cn/Article/CJFDTOTAL-YSLX2010S2099.htm
[22]	赵东平, 沈振东, 王风, 等. 砂卵石泥岩复合地层盾构隧道施工导致的地表沉降槽宽度计算方法研究[J]. 现代隧道技术, 2022, 59(S1): 32-41. https://www.cnki.com.cn/Article/CJFDTOTAL-XDSD2022S1004.htm Zhao Dongping, Shen Zhendong, Wang Feng, et al. Study on calculation method of surface settlement trough width caused by shield tunneling in sandy pebble mudstone composite stratum[J]. Modern Tunnelling Technology, 2022, 59(S1): 32-41. https://www.cnki.com.cn/Article/CJFDTOTAL-XDSD2022S1004.htm
[23]	吴锋波, 郑卫强, 齐剑峰, 等. 地铁双线盾构区间地表横向沉降槽参数分析[J]. 地下空间与工程学报, 2021, 17(5): 1653-1663. https://www.cnki.com.cn/Article/CJFDTOTAL-BASE202105037.htm Wu Fengbo, Zheng Weiqiang, Qi Jianfeng, et al. The ground transverse settlement tank parameters analysis of subway double line shield section[J]. Chinese Journal of Underground Space and Engineering, 2021, 17(5): 1653-1663. https://www.cnki.com.cn/Article/CJFDTOTAL-BASE202105037.htm
[24]	刘波, 杨伟红. 考虑时间效应的隧道开挖三维沉降预测模型及应用[J]. 矿业科学学报, 2019, 4(5): 384-393. http://kykxxb.cumtb.edu.cn/article/id/237 Liu Bo, Yang Weihong. Prediction model and application of three-dimensional ground surface settlement induced by tunnel excavation considering time effect[J]. Journal of Mining Science and Technology, 2019, 4(5): 384-393. http://kykxxb.cumtb.edu.cn/article/id/237
[25]	韦征, 江玉生. 基于Timoshenko梁的盾构上跨对既有隧道纵向变形影响研究[J]. 矿业科学学报, 2021, 6(1): 30-41. doi: 10.19606/j.cnki.jmst.2021.01.004 Wei Zheng, Jiang Yusheng. Study on the influence of above-crossing tunneling on the existing shield tunnels based on Timoshenko beam[J]. Journal of Mining Science and Technology, 2021, 6(1): 30-41. doi: 10.19606/j.cnki.jmst.2021.01.004
[26]	Huai P S, An H B, Bai X L, et al. Type selection of shields in water-rich kurkar stratum in Israel[J]. Tunnel Construction, 2020, 40(2): 276-282.

Relative Articles

Supplements(0)

Cited By

Proportional views

Proportional views

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Figures(12) / Tables(3)

Get Citation

PDF

XML

Article Metrics

Article views (168) PDF downloads(21)

Study on the strata displacement law of overlapping shield tunnels with different overlapping angles

doi: 10.19606/j.cnki.jmst.2023.04.008

Abstract

References

Proportional views

Catalog

通讯作者: 陈斌, bchen63@163.com

Article Metrics

Proportional views

Export File

Citation

Format

Content