Study on the law of influence by slurry viscosity on the fractured aquifer grouting and diffusion

Xu Yanchun; Zhang Ermeng; Zhao Lin; Shen Xingyu; Li Zhiyu

doi:10.19606/j.cnki.jmst.2021.01.008

Volume 6 Issue 1

Mar. 2021

Turn off MathJax

Article Contents

Article Navigation > Journal of Mining Science and Technology > 2021 > 6(1): 71-81

Xu Yanchun, Zhang Ermeng, Zhao Lin, Shen Xingyu, Li Zhiyu. Study on the law of influence by slurry viscosity on the fractured aquifer grouting and diffusion[J]. Journal of Mining Science and Technology, 2021, 6(1): 71-81. doi: 10.19606/j.cnki.jmst.2021.01.008

Citation:

PDF( 16260 KB)

Study on the law of influence by slurry viscosity on the fractured aquifer grouting and diffusion

doi: 10.19606/j.cnki.jmst.2021.01.008

School of Energy and Mining Engineering, China University of Mining & Technology-Beijing, Beijing 100083, China

Received Date: 2020-01-06
Rev Recd Date: 2020-05-20
Publish Date: 2021-02-01

Abstract

Abstract

This study is to investigate the influence of slurry viscosity on the diffusion and filling of slurry during grouting reinforcement. Firstly, based on the newly developed test device, the diffusion process of three kinds of viscosity slurry in the aquifer of confined aquifer was simulated, and the law of slurry diffusion and filling was summarized. Fluent was adopted to simulate the grouting process. The stress distribution and variation law during the filling process of different viscosity slurries was obtained, the abnormal phenomena appearing in the physical test process was explained, and the elastic modulus of the rock mass after different viscosity slurry transformation by ultrasonic measurement was obtained. The results show that: In the process of high-viscosity slurrygouting, the formation of high-stressed cracks in the region is irregularly developed, and the slurry diffusion is deflected to the right; Under the same stress, the elastic modulus(λ)of the rock block is proportional to the viscosity of the slurry(μ_e), and the λ_max=108.07 % (μ_e=16.67)in the experiment; The medium viscosity slurry has a good transformation effect, and the area of the non-complete filling area is 23.35 %, and no abnormal phenomenon such as slurry accumulation occurs.
- Fractured aquifer,
- grouting and diffusion,
- physical simulation,
- numerical simulation

FullText(HTML)

References(27)

References

[1]	施龙青, 邱梅, 牛超, 等. 肥城煤田奥灰顶部注浆加固可行性分析[J]. 采矿与安全工程学报, 2015, 32(3): 356-362. https://www.cnki.com.cn/Article/CJFDTOTAL-KSYL201503002.htm Shi Longqing, Qiu Mei, Niu Chao, et al. Feasibility analysis of grouting reinforcement of Ordovician top in Feicheng coalfield[J]. Journal of Mining & Safety Engineering, 2015, 32(3): 356-362. https://www.cnki.com.cn/Article/CJFDTOTAL-KSYL201503002.htm
[2]	崔芳鹏, 武强, 林元惠, 等. 中国煤矿水害综合防治技术与方法研究[J]. 矿业科学学报, 2018, 3(3): 219-228. doi: 10.19606/j.cnki.jmst.2018.03.002 Cui Fangpeng, Wu Qiang, Lin Yuanhui, et al. Prevention and control techniques & methods for water disasters at coal mines in China[J]. Journal of Mining Science and Technology, 2018, 3(3): 219-228. doi: 10.19606/j.cnki.jmst.2018.03.002
[3]	李慎举, 崔芳鹏, 武强, 等. 霍宝干河煤矿10号煤层底板突水危险性评价与防治[J]. 矿业科学学报, 2016, 1(1): 9-15. http://www.cnki.com.cn/Article/CJFDTotal-KYKX201601003.htm Li Shenju, Cui Fangpeng, Wu Qiang, et al. Evaluation and prevention of water hazards of the bottom plate of the 10th coal seam of the Hobogan River Coal Mine[J]. Journal of Mining Science and Technology, 2016, 1(1): 9-15. http://www.cnki.com.cn/Article/CJFDTotal-KYKX201601003.htm
[4]	赵庆彪. 奥灰岩溶水害区域超前治理技术研究及应用[J]. 煤炭学报, 2014, 39(6): 1112-1117. https://www.cnki.com.cn/Article/CJFDTOTAL-MTXB201406020.htm Zhao Qingbiao. Ordovician limestone karst water disaster regional advanced governance technology study and application[J]. Journal of China Coal Society, 2014, 39(6): 1112-1117. https://www.cnki.com.cn/Article/CJFDTOTAL-MTXB201406020.htm
[5]	许延春, 李见波. 注浆加固工作面底板突水"孔隙-裂隙升降型"力学模型[J]. 中国矿业大学学报2014, 43(1): 49-55. https://www.cnki.com.cn/Article/CJFDTOTAL-ZGKD201401008.htm Xu Yanchun, Li Jianbo, "Pore-fractured lifting type"mechanical model for floor water inrush of the grouting enforcement working face[J]. Journal of China University of Mining & Technology, 2014, 43(1): 49-55. https://www.cnki.com.cn/Article/CJFDTOTAL-ZGKD201401008.htm
[6]	王国际. 注浆技术理论与实践[M]. 徐州: 中国矿业大学出版社, 2000.
[7]	何文瑞, 何富连, 张坤, 等. 淋水软弱巷道注浆加固扩散机理与参数优化的研究[J]. 矿业科学学报, 2019, 4(3): 221-229. http://www.cnki.com.cn/Article/CJFDTotal-KYKX201903004.htm He wenrui, He fulian, Zhang kun, et al. Diffusion mechanism and parameter optimization in the process of grouting reinforcement of drenching and soft roadway[J]. Journal of Mining Science and Technology, 2019, 4(3): 221-229. http://www.cnki.com.cn/Article/CJFDTotal-KYKX201903004.htm
[8]	Karol R H.Grout penetrability[C]//Issues in Dam Grouting.ASCE, 2010: 27-33.
[9]	岩土注浆理论与工程实践协作组. 岩土注浆理论与工程实践[M]. 北京: 科学出版社, 2001.
[10]	王苏健, 陈通, 李涛, 等. 承压水体上保水采煤注浆材料及技术[J]. 煤炭学报, 2017, 42(1): 134-139. https://www.cnki.com.cn/Article/CJFDTOTAL-MTXB201701018.htm Wang Sujian, Chen Tong, Li Tao, et al. Grouting material and technique in water protection mining above confined water[J]. Journal of China Coal Society, 2017, 42(1);134-139. https://www.cnki.com.cn/Article/CJFDTOTAL-MTXB201701018.htm
[11]	王强, 冯志强, 王理想, 等. 裂隙岩体注浆扩散范围及注浆量数值模拟[J]. 煤炭学报, 2016, 41(10): 2588-2595. https://www.cnki.com.cn/Article/CJFDTOTAL-MTXB201610027.htm Wang Qiang, Feng Zhiqiang, Wang Lixiang, et al. Numerical analysis of grouting radius and grout quantity in fractured rock mass[J]. Journal of China Coal Society, 2016, 41(10): 2588-2595. https://www.cnki.com.cn/Article/CJFDTOTAL-MTXB201610027.htm
[12]	杨仁树, 薛华俊, 郭东明, 等. 基于注浆试验的深井软岩CT分析[J]. 煤炭学报, 2016, 41(2): 345-351. https://www.cnki.com.cn/Article/CJFDTOTAL-MTXB201602010.htm Yang Renshu, Xue Huajun, Guo Dongming, et al. Laboratory grouting experiment based CT analysis of grouted soft rocks in deep mines[J]. Journal of China Coal Society, 2016, 41(2): 345-351. https://www.cnki.com.cn/Article/CJFDTOTAL-MTXB201602010.htm
[13]	Oka F, Kodaka T, Ohno Y.Applicability of permeation grouting method using colloidal silica for coral sand[J]. Doboku Gakkai Ronbunshuu C, 2008, 64(3): 571-584. doi: 10.2208/jscejc.64.571
[14]	Wang S Y, Chan D, Lam K C.Experimental study of the effect of fines content on dynamic compaction grouting in completely decomposed granite of Hong Kong[J]. Construction and Building Materials, 2009, 23(3): 1249-1264. doi: 10.1016/j.conbuildmat.2008.08.002
[15]	Wang S Y, Chan D H, Lam K C, et al. Numerical and experimental studies of pressure-controlled cavity expansion in completely decomposed granite soils of Hong Kong[J]. Computers and Geo technics, 2010, 37(7/8): 977-990. http://www.sciencedirect.com/science/article/pii/S0266352X10001102
[16]	Masumoto K, Sugita Y, Fujita T, et al. A clay grouting technique for granitic rock adjacent to clay bulkhead[J]. Physics and Chemistry of the Earth, 2006, 32(8): 691-700. http://www.sciencedirect.com/science/article/pii/S1474706506002622
[17]	Shen S L, Wang Z F, Horpibulsuk S, et al. Jet grouting with a newly developed technology: the Twin-Jet method[J]. Engineering Geology, 2013, 152(1): 87-95. doi: 10.1016/j.enggeo.2012.10.018
[18]	赵庆彪, 毕超, 虎维岳, 等. 裂隙含水层水平孔注浆"三时段"浆液扩散机理研究及应用[J]. 煤炭学报, 2016, 41(5): 1212-1218. https://www.cnki.com.cn/Article/CJFDTOTAL-MTXB201605021.htm Zhao Qingbiao, Bi Chao, Hu Weiyue, et al. Study and application of three-stage seriflux diffusion mechanism in the fissure of aquifer with horizontal injection hole[J]. Journal of China Coal Society, 2016, 41(5): 1212-1218. https://www.cnki.com.cn/Article/CJFDTOTAL-MTXB201605021.htm
[19]	江明明. 深厚破碎岩体巷道围岩地面注浆加固技术研究[D]. 淮南: 安徽理工大学, 2014.
[20]	李召峰. 富水破碎岩体注浆材料研发与注浆加固机理研究及应用[D]. 济南: 山东大学, 2016.
[21]	文圣勇. 深埋煤岩体注浆加固效应与控制参数研究[D]. 徐州: 中国矿业大学, 2015.
[22]	刘泉声, 邓鹏海, 毕晨, 等. 深部巷道软弱围岩破裂碎胀过程及锚喷-注浆加固FDEM数值模拟[J]. 岩土力学, 2019, 40(10): 4065-4083. https://www.cnki.com.cn/Article/CJFDTOTAL-YTLX201910043.htm Liu Quansheng, Deng Penghai, Bi Chen, et al. FDEM numerical simulation of the fracture and extraction process of soft surrounding rock mass and its rockbolt-shotcrete-grouting reinforcement methods in the deep tunnel[J]. Rock and soil Mechanics, 2019, 40(10): 4065-4083. https://www.cnki.com.cn/Article/CJFDTOTAL-YTLX201910043.htm
[23]	Pitt M J, Liu Haijun. Mars funnel and drilling fluid viscosity: a new equation for oil field applications[J]. Foreign Oilfield Engineering, 2001(12): 28-31.
[24]	叶茂, 伍超, 陈云良, 等. FLUENT软件在水利工程中的应用[J]. 水利水电科技进展, 2006, 26(3): 78-81. doi: 10.3880/j.issn.1006-7647.2006.03.021 Ye Mao, Wu Chao, Chen Yunliang, et al. Application of FLUENT to hydraulic projects[J]. Advances in Science and Technology of Water Resources, 2006, 26(3): 78-81. doi: 10.3880/j.issn.1006-7647.2006.03.021
[25]	王晓. 煤矿用废气处理箱的数值仿真及试验[J]. 煤炭学报, 2019, 44(S2): 737-745. https://www.cnki.com.cn/Article/CJFDTOTAL-MTXB2019S2039.htm Wang Xiao. Numerical simulation and test of waste gas treatment tank used in coal mine[J]. Journal of China Coal Society, 2019, 44(S2): 737-745. https://www.cnki.com.cn/Article/CJFDTOTAL-MTXB2019S2039.htm
[26]	刘世奇, 许延春, 费宇, 等. 声波检测技术在裂隙岩体注浆加固工程质量检测中的应用[J]. 西安科技大学学报, 2018, 38(3): 396-402. https://www.cnki.com.cn/Article/CJFDTOTAL-XKXB201803009.htm Liu Shiqi, Xu Yanchun, Fei Yu, et al. Application of ultrasonic testing technology to quality inspection of grouting reinforcement in fractured rock mass[J]. Journal of Xi'an University of Science and Technology, 2018, 38(3): 396-402. https://www.cnki.com.cn/Article/CJFDTOTAL-XKXB201803009.htm
[27]	许延春, 谢小峰, 刘世奇, 等. 注浆加固工作面底板岩体力学性质"增强-损伤"的定量测定[J]. 采矿与安全工程学报, 2017, 34(6): 1186-1193. https://www.cnki.com.cn/Article/CJFDTOTAL-KSYL201706024.htm Xu Yanchun, Xie Xiaofeng, Liu Shiqi, et al. Quantitative determination of mechanical property of "enhance-damage"for floor rock mass in grouting reinforcement working face[J]. Journal of Mining & Safety Engineering, 2017, 34(6): 1186-1193. https://www.cnki.com.cn/Article/CJFDTOTAL-KSYL201706024.htm

Relative Articles

Supplements(0)

Cited By

Proportional views

Proportional views

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Figures(16) / Tables(3)

Get Citation

PDF

XML

Article Metrics

Article views (428) PDF downloads(30)

Study on the law of influence by slurry viscosity on the fractured aquifer grouting and diffusion

doi: 10.19606/j.cnki.jmst.2021.01.008

Abstract

References

Proportional views

Catalog

通讯作者: 陈斌, bchen63@163.com

Article Metrics

Proportional views

Export File

Citation

Format

Content