Biodegradation characteristics of phenol and quinoline by Alcaligenes faecalis and its immobilization application
-
摘要: 苯酚和喹啉单基质降解菌在实际应用中局限性较大,筛选共基质条件下具有生物降解活性的菌株更具有实际价值。从焦化厂废水处理系统的污泥中经过驯化、分离,筛选出一株能同时降解苯酚和喹啉的菌株KD1,根据形态特征、生理生化和16S rDNA序列等分析,鉴定其为粪产碱杆菌(Alcaligenes faecalis)。降解条件优化表明,菌株KD1有较好的酸碱度适用性,在接菌量为10 %、初始pH值为7.0、温度35 ℃、振荡器转速150 r/min时,对苯酚和喹啉的降解效率最高;氮源能影响菌株KD1对苯酚的降解,而共基质下菌株KD1能协同降解苯酚和喹啉。菌株KD1能完全降解700 mg/L的苯酚和400 mg/L的喹啉,降解过程均呈零级反应特征,其在不同浓度的苯酚和喹啉中的生长符合Haldane底物抑制模型,抑制浓度分别为293 mg/L和229 mg/L。固定化研究表明,通过包埋和吸附制备的新型固定化载体能提高菌株KD1对苯酚和喹啉共基质的降解效率。Abstract: The strains that can only degrade phenol or quinoline are limited in practical application. It is more practical to select the tolerant strains which can degrade the compound pollutants. A phenol-quinoline degrading strain KD1 was isolated from activated sludge in a coke-plant wastewater treatment system. KD1 was identified as Alcaligenes faecalis on the basis of morphological characteristics, physiological and biochemical characteristics and the analysis of its 16S rDNA sequence. The optimal degradation conditions showed that strain KD1 had good pH applicability, and the optimal conditions were as follow: inoculation volume 10 %, rotation rate 150 r/min, culture temperature 30 ℃, initial pH value 7.0 respectively. Nitrogen source can affect the degradation of phenol by strain KD1, while strain KD1 can synergistically degrade phenol and quinoline under co-substrate. The degradation reaction of phenol and quinoline can be described with zero order kinetic equation within 700 mg/L phenol and 400 mg/L respectively. The growth kinetics of Strain KD1 could be described with Haldanes inhibition model, and the inhibition concentrations of it were 293 mg/L and 229 mg/L, respectively. The new immobilized carrier prepared by embedding and adsorption can improve the degradation efficiency of co-substrate pollutants.
-
Key words:
- phenol /
- quinoline /
- co-degradation /
- degradation characteristics /
- immobilization
-
表 1 KD1的生理生化特性
Table 1. Physio-biochemical characteristics of KD1
指标 革兰氏染色 水解淀粉酶 葡萄糖 过氧化氢酶 水解明胶试验 与氧气的关系 结果 - - + + + + -
[1] Zhu H, Han Y X, Ma W C, et al. Removal of selected nitrogenous heterocyclic compounds in biologically pretreated coal gasification wastewater (BPCGW)using the catalytic ozonation process combined with the two-stage membrane bioreactor (MBR)[J]. Bioresource Technology, 2017, 245: 786-793. doi: 10.1016/j.biortech.2017.09.029 [2] Shahryari S, Zahiri H S, Haghbeen K, et al. High phenol degradation capacity of a newly characterized Acinetobacter sp. SA01: Bacterial cell viability and membrane impairment in respect to the phenol toxicity[J]. Ecotoxicology and Environmental Safety, 2018, 164: 455-466. doi: 10.1016/j.ecoenv.2018.08.051 [3] Basak B, Jeon B H, Kurade M B, et al. Biodegradation of high concentration phenol using sugarcane bagasse immobilized Candida tropicalis PHB5 in a packed-bed column reactor[J]. Ecotoxicology and Environmental Safety, 2019, 180: 317-325. doi: 10.1016/j.ecoenv.2019.05.020 [4] Paisio C E, Talano M A, González P S, et al. Isolation and characterization of a Rhodococcus strain with phenol-degrading ability and its potential use for tannery effluent biotreatment[J]. Environmental Science and Pollution Research, 2012, 19(8): 3430-3439. doi: 10.1007/s11356-012-0870-8 [5] Yi T, Shan Y, Huang B, et al. An efficient Chlorella sp. "Cupriavidus" necator microcosm for phenol degradation and its cooperation mechanism[J]. Science of the Total Environment, 2020, 743: 140775. doi: 10.1016/j.scitotenv.2020.140775 [6] Li C M, Wu H Z, Wang Y X, et al. Enhancement of phenol biodegradation: Metabolic division of labor in co-culture of Stenotrophomonas sp. N5 and Advenella sp. B9[J]. Journal of Hazardous Materials, 2020, 400: 123214. doi: 10.1016/j.jhazmat.2020.123214 [7] Jiang Y, Deng T, Shang Y, et al. Biodegradation of phenol by entrapped cell of Debaryomyces sp. with nano-Fe3O4 under hypersaline conditions[J]. International Biodeterioration & Biodegradation, 2017, 123: 37-45. [8] Qiao L, Wang J L. Biodegradation characteristics of quinoline by Pseudomonas putida[J]. Bioresource Technology, 2010, 101(19): 7683-7686. doi: 10.1016/j.biortech.2010.05.026 [9] Zhang P, Jia R, Zhang Y, et al. Quinoline-degrading strain Pseudomonas aeruginosa KDQ4 isolated from coking activated sludge is capable of the simultaneous removal of phenol in a dual substrate system[J]. Journal of Environmental Science and Health, Part A, 2016, 51(13): 1139-1148. doi: 10.1080/10934529.2016.1206377 [10] 徐伟超, 吴翠平, 张玉秀, 等. 喹啉降解菌Ochrobactrum sp. 的好氧降解特性及其在焦化废水中的生物强化作用[J]. 环境科学, 2017, 38(5): 2030-2035. https://www.cnki.com.cn/Article/CJFDTOTAL-HJKZ201705040.htmXu Weichao, Wu Cuiping, Zhang Yuxiu, et al. Aerobic degradation characteristics of the quinoline-degrading strain Ochrobactrum sp. and its bioaugmentation in coking wastewater[J]. Environmental Science, 2017, 38(5): 2030-2035. https://www.cnki.com.cn/Article/CJFDTOTAL-HJKZ201705040.htm [11] Tuo B H, Yan J B, Fan B A, et al. Biodegradation characteristics and bioaugmentation potential of a novel quinoline-degrading strain of Bacillus sp. isolated from petroleum-contaminated soil[J]. Bioresource Technology, 2012, 107: 55-60. doi: 10.1016/j.biortech.2011.12.114 [12] Wang J L, Quan X C, Han L P, et al. Microbial degradation of quinoline by immobilized cells of Burkholderia pickettii[J]. Water Research, 2002, 36(9): 2288-2296. doi: 10.1016/S0043-1354(01)00457-2 [13] Kurade M B, Waghmode T R, Xiong J Q, et al. Decolorization of textile industry effluent using immobilized consortium cells in upflow fixed bed reactor[J]. Journal of Cleaner Production, 2019, 213: 884-891. doi: 10.1016/j.jclepro.2018.12.218 [14] Ke Q, Zhang Y G, Wu X L, et al. Sustainable biodegradation of phenol by immobilized Bacillus sp. SAS19 with porous carbonaceous gels as carriers[J]. Journal of Environmental Management, 2018, 222: 185-189. [15] 东秀珠, 蔡妙英. 常见细菌系统鉴定手册[M]. 北京: 科学出版社, 2001. [16] 国家环境保护总局. 水和废水检测分析方法[M]. 北京: 中国环境科学出版社, 2002. [17] 李亚新, 赵晨红. 紫外分光光度法测定焦化废水的主要污染物[J]. 中国给水排水, 2001, 17(1): 54-56. doi: 10.3321/j.issn:1000-4602.2001.01.016Li Yaxin, Zhao Chenhong. Determination of main pollutants in coking wastewater by UV spectrophotometry[J]. China Water & Wastewater, 2001, 17(1): 54-56. doi: 10.3321/j.issn:1000-4602.2001.01.016 [18] Wang S J, Loh K C. Modeling the role of metabolic intermediates in kinetics of phenol biodegradation[J]. Enzyme and Microbial Technology, 1999, 25(3/4/5): 177-184. http://www.ingentaconnect.com/content/els/01410229/1999/00000025/00000003/art00060 [19] 钟卓亚. 微波辅助化学活化制备活性炭的研究[D]. 长沙: 湖南大学, 2012. [20] 李静, 李文英. 喹啉降解菌筛选及其对焦化废水强化处理[J]. 环境科学, 2015, 36(4): 1385-1391. https://www.cnki.com.cn/Article/CJFDTOTAL-HJKZ201504039.htmLi Jing, Li Wenying. Screening of a Highly Efficient Quinoline-degrading Strain and Its Enhanced Biotreatment on Coking Waste Water[J]. Environmental Science, 2015, 36(4): 1385-1391. https://www.cnki.com.cn/Article/CJFDTOTAL-HJKZ201504039.htm [21] 张玉秀, 豆梦楠, 朱康兴, 等. 喹啉降解菌Rhodococcus sp. 的降解特性与生物强化作用[J]. 中国环境科学, 2017, 37(6): 2340-2346. doi: 10.3969/j.issn.1000-6923.2017.06.043Zhang Yuxiu, Dou Mengnan, Zhu Kangxing, et al. Bioaugmentation and characteristics of a quinoline-degrading strain Rhodococcus sp. [J]. China Environmental Science, 2017, 37(6): 2340-2346. doi: 10.3969/j.issn.1000-6923.2017.06.043 [22] 王培明, 霍明昕, 朱遂一, 等. 低温喹啉降解菌的筛选及降解性能[J]. 环境工程学报, 2013, 7(1): 154-158. https://www.cnki.com.cn/Article/CJFDTOTAL-HJJZ201301029.htmWang Peiming, Huo Mingxin, Zhu Suiyi, et al. Screening of quinoline-degradation bacteria and their biodegradation capability at low temperature[J]. Chinese Journal of Environmental Engineering, 2013, 7(1): 154-158. https://www.cnki.com.cn/Article/CJFDTOTAL-HJJZ201301029.htm [23] 陈晓华, 魏刚, 刘思远, 等. 高效降酚菌株Ochrobactrum sp. CH10生长动力学和苯酚降解特性的研究[J]. 环境科学, 2012, 33(11): 3956-3961. https://www.cnki.com.cn/Article/CJFDTOTAL-HJKZ201211039.htmChen Xiaohua, Wei Gang, Liu Siyuan, et al. Growth kinetics and phenol degradation of highly efficient phenol-degrading Ochrobactrum sp. CH10[J]. Environmental Science, 2012, 33(11): 3956-3961. https://www.cnki.com.cn/Article/CJFDTOTAL-HJKZ201211039.htm [24] Wang Y, Chen H, Liu Y X, et al. An adsorption-release-biodegradation system for simultaneous biodegradation of phenol and ammonium in phenol-rich wastewater[J]. Bioresource Technology, 2016, 211: 711-719. doi: 10.1016/j.biortech.2016.03.149 [25] Li Y, Li J, Wang C, et al. Growth kinetics and phenol biodegradation of psychrotrophic Pseudomonas putida LY1[J]. Bioresource Technology, 2010, 101(17): 6740-6744. doi: 10.1016/j.biortech.2010.03.083 [26] 陈春, 李文英, 吴静文, 等. 焦化废水中苯酚降解菌筛选及其降解性能[J]. 环境科学, 2012, 33(5): 1652-1656. https://www.cnki.com.cn/Article/CJFDTOTAL-HJKZ201205039.htmChen Chun, Li Wenying, Wu Jingwen, et al. Screening and characterization of phenol degrading bacteria for the coking wastewater treatment[J]. Environmental Science, 2012, 33(5): 1652-1656. https://www.cnki.com.cn/Article/CJFDTOTAL-HJKZ201205039.htm [27] 魏霞, 周俊利, 谢柳, 等. 苯酚降解菌CM-HZX1菌株的分离、鉴定及降解性能研究[J]. 环境科学学报, 2016, 36(9): 3193-3199. https://www.cnki.com.cn/Article/CJFDTOTAL-HJXX201609010.htmWei Xia, Zhou Junli, Xie Liu, et al. Isolation, identification and characterization of phenol-degrading strain CM-HZX1[J]. Acta Scientiae Circumstantiae, 2016, 36(9): 3193-3199. https://www.cnki.com.cn/Article/CJFDTOTAL-HJXX201609010.htm [28] 卫晓博, 侯颖, 程豪杰, 等. 一种苯酚降解菌Pseudoxanthomonas sp. BF-6的分离鉴定及其降解特性、降解途径研究[J]. 生物技术通报, 2021, 37(11): 30-38. https://www.cnki.com.cn/Article/CJFDTOTAL-SWJT202110009.htmWei Xiaobo, Hou Ying, Cheng Haojie, et al. Isolation, Identification of Phenol-degrading Pseudoxanthomonas sp. BF-6 and Its Degradation Characterization and Pathway[J]. Biotechnology Bulletin, 2021, 37(11): 30-38. https://www.cnki.com.cn/Article/CJFDTOTAL-SWJT202110009.htm [29] 周集体, 关晓燕, 曲媛媛, 等. 苯酚降解菌株GXY-1分离鉴定、降解及其粗酶特性研究[J]. 大连理工大学学报, 2010, 50(3): 340-345. https://www.cnki.com.cn/Article/CJFDTOTAL-DLLG201003007.htmZhou Jiti, Guan Xiaoyan, Qu Yuanyuan, et al. Research on isolation, identification of a phenol-degrading strain GXY-1 and characteristics of its degradation and crude enzyme[J]. Journal of Dalian University of Technology, 2010, 50(3): 340-345. https://www.cnki.com.cn/Article/CJFDTOTAL-DLLG201003007.htm [30] Kilic N K. Enhancement of phenol biodegradation by Ochrobactrum sp. isolated from industrial wastewaters[J]. International Biodeterioration & Biodegradation, 2009, 63(6): 778-781. http://www.onacademic.com/detail/journal_1000034018543910_3ae1.html [31] Zhu S N, Liu D Q, Fan L, et al. Degradation of quinoline by Rhodococcus sp. QL2 isolated from activated sludge[J]. Journal of Hazardous Materials, 2008, 160(2/3): 289-294. [32] 唐春燕, 李巍, 叶秋霞, 等. 恶臭假单胞菌降解苯酚的动力学研究[J]. 环境工程学报, 2011, 5(10): 2364-2368. https://www.cnki.com.cn/Article/CJFDTOTAL-HJJZ201110039.htmTang Chunyan, Li Wei, Ye Qiuxia, et al. Growth kinetics and phenol biodegradation of Pseudomonas putida LY1[J]. Chinese Journal of Environmental Engineering, 2011, 5(10): 2364-2368. https://www.cnki.com.cn/Article/CJFDTOTAL-HJJZ201110039.htm [33] Wang G Y, Wen J P, Yu G H, et al. Anaerobic biodegradation of phenol by Candida albicans PDY-07 in the presence of 4-chlorophenol[J]. World Journal of Microbiology and Biotechnology, 2008, 24(11): 2685-2691. doi: 10.1007/s11274-008-9797-0 [34] 葛启隆, 王国英, 岳秀萍. 波茨坦短芽孢杆菌降解苯酚特性及动力学研究[J]. 生物技术通报, 2014(3): 117-122. https://www.cnki.com.cn/Article/CJFDTOTAL-SWJT201403020.htmGe Qilong, Wang Guoying, Yue Xiuping. Phenol degradation by brevibacillus borstelensis and kinetic analysis[J]. Biotechnology Bulletin, 2014(3): 117-122. https://www.cnki.com.cn/Article/CJFDTOTAL-SWJT201403020.htm [35] 侯思宇. 喹啉降解菌的筛选及活化条件对喹啉降解速率的影响[D]. 西安: 西安建筑科技大学, 2017. [36] 朱顺妮, 刘冬启, 樊丽, 等. 喹啉降解菌Rhodococcus sp. QL2的分离鉴定及降解特性[J]. 环境科学, 2008, 29(2): 2488-2493. https://www.cnki.com.cn/Article/CJFDTOTAL-HJKZ200802036.htmZhu Shunni, Liu Dongqi, Fan Li, et al. Isolation, identification and degradation characteristics of a quinoline-degrading bacterium Rhodococcus sp. QL2[J]. Environmental Science, 2008, 29(2): 2488-2493. https://www.cnki.com.cn/Article/CJFDTOTAL-HJKZ200802036.htm