Effects of maceral composition on vitrinite reflectance distribution of blended coals
-
摘要: 为了探究煤显微组分组成对配煤镜质体反射率分布的影响,本研究建立了基于配合单煤镜质体反射率分布、镜质组含量及配入比例的配煤镜质体反射率分布的预测方法,同时以开滦矿区4种不同变质程度烟煤(Ro,ran介于0.88%~1.30%)为研究对象,利用软件Design-Expert 8.0进行配煤镜质体反射率分布影响因素及其显著性分析。三因素显著性分析结果表明,相比于镜质组含量和配入比例,参与配煤的单煤镜质体反射率是影响配煤镜质体反射率分布的显著性因素;当各配合单煤镜质体反射率确定时,两因素显著性分析结果表明,镜质组含量和配入比例均是影响配煤镜质体反射率分布的显著性因素。Abstract: In order to investigate the effects of maceral composition on vitrinite reflectance distribution of blended coals,this paper established the technique of predicting vitrinite reflectance distribution of blended coals in terms of vitrinite reflectance distribution of single blending coal,vitrinite content and blending ratio,and the influencing factors and their significant analysis of vitrinite reflectance distribution of blended coals using Software Design-Expert 8.0 were performed based on four coals with vitrinite reflectance (Ro,ran) varying from 0.88% to 1.30% in Kailuan coalfield. Results of the significant analysis with three factors show that compared to vitrinite content and blending ratio,the vitrinite reflectance of single blending coal is a significant factor influencing vitrinite reflectance distribution of blended coal;when vitrinite reflectance distribution of single blending coal is fixed,results of the significant analysis with two factors show that both vitrinite content and blending ratio affect the vitrinite reflectance distribution significantly.
-
[1] Gagarin S G.Molecular models of coals organic matter and the reflectance of the macerals:a review [J].Coke and Chemistry,2012,55(11):409-418. [2] 陈鹏.中国煤炭性质、分类和利用[M].北京:化学工业出版社,2001:36-44. [3] 燕瑞华,高志军,耿印权,等.镜质组反射率分布图在配煤炼焦中的应用[J].燃料与化工,2001,32(5):227-230. [4] Yan Ruihua,Gao Zhijun,Geng Yinquan,et al.Application of vitrinite reflectance distribution figure in coal blending and cokemaking [J].Fuel & Chemical Process,2001,32(5):227-230. [5] 陈志强,李军,齐正义.煤镜质组反射率分布图在配煤系统中的应用[J].煤炭工程,2015,47(10):125-127. [6] Chen Zhiqiang,Li Jun,Qi Zhengyi.Application of vitrinite reflectance distribution diagram in comprehensive and efficient utilization system of raw coal [J].Coal Engineering,2015,47(10):125-127. [7] Suarez-Ruiz I,Crelling J C.Applied coal petrography:the role of petrography in coal utilization [M].San Diego:Academic Press,2008:58-59. [8] 孟庆波,刘洋,郭武卫,等.基于镜质组反射率分布的水钢优化配煤研究[J].煤炭转化,2011,34(1):22-28. [9] Meng Qingbo,Liu Yang,Guo Wuwei,et al.Optimization of coal blending about Shuicheng steel based on reflectance distribution of coal vitrinite [J].Coal Conversion,2011,34(1):22-28. [10] 项茹,薛改凤,陈鹏,等.炼焦煤镜质组反射率分布对焦炭显微结构和热性能的影响[J].煤化工,2007,132(5):47-49. [11] Xiang Ru,Xue Gaifeng,Chen Peng,et al.Effect of vitrinite reflectance distribution of coking coal on microstructure and thermal properties of coke [J].Coal Chemical Industry,2007,132 (5):47-49. [12] Crelling J C,Skorupska N M,Marsh H.Reactivity of coal macerals and lithotype [J].Fuel,1988,67(6):781-785. [13] Das T K.Thermogravimetric characterization of coal maceral concentrates of Russian coking coals [J].Fuel,2001,80(1):97-106. [14] Francisszek C,Kidawa H.Reactivity and susceptibility to porosity development of coal maceral char on steam and carbon dioxide gasification [J].Fuel Processing Technology,1991,29(1/2):57-73. [15] Keogh R A,Taulbee D N,Hower J C,et al.Liquefaction characteristics of the three major maceral groups separated from a single coal [J].Energy and Fuels,1992,6(5):614-618. [16] 吴国光,李建亮,孟献梁,等.煤岩组成与水煤浆成浆性能的关系研究[J].中国矿业大学学报,2009,38(2):209-213. [17] Wu Guoguang,Li Jiangliang,Meng Xianliang,et al.Research on the relationship between slurryability and petrological composition of coal [J].Journal of China University of Mining & Technology,2009,38(2):209-213. [18] 晋香兰,降文萍,李小彦,等.低煤阶煤的煤岩组分液化性能及实验研究[J].煤炭学报,2010,35(6):992-997. [19] Jin Xianglan,Jiang Wenping,Li Xiaoyan,et al.Liquefaction properties and experiment on lithotype of low rank coal [J].Journal of China Coal Society,2010,35(6):992-997. [20] 李文华,白向飞,陈金和,等.烟煤镜质组平均最大反射率与煤种之间的关系[J].煤炭学报,2006,31(3):342-345. [21] Li Wenhua,Bai Xiangfei,Chen Jinhe,et al.Correspondence between mean maximum reflectance of vit-rinite and classification of bituminous [J].Journal of China Coal Society,2006,31 (3):342-345. [22] 姚昭章,郑明东.炼焦学[M].3版.北京:冶金工业出版社,2005:61-75. [23] Spackman W.The maceral concept and the study of modern environments as a means of understanding the nature of coal [J].Transactions of the New York Academy of Sciences,1958,20 (5):411-423. [24] Zhang Lei,Liu Wenli,Men Dongpo.Preparation and coking properties of coal maceral concentrates [J].International Journal of Mining Science and Technology,2014,24(1):93-98. [25] Honaker R Q,Mohanty M K,Crelling J C.Coal maceral separation using column flotation [J].Minerals Engineering,1996,9(4):449-464. [26] Zhang Lei,Hower J C,Honaker R Q,et al.Flotation rates and zeta potentials of maceral concentrates of bituminous coals [J].Minerals & Metallurgical Processing,2015,32(3):129-137. [27] 张雅茹,徐君,曲恒.炼焦煤镜质组反射率及其分布可加和性的研究[J].现代化工,2009,29(增1):59-61. [28] Zhang Yaru,Xu Jun,Qu Heng.Research of mean max reflectance and distribution curve of coking coals [J].Modern Chemical Industry,2009,29(S1):59-61. [29] 张磊,刘文礼,门东坡,等.炼焦煤镜质组反射率直方图及其加和性[J].辽宁工程技术大学学报:自然科学版,2013,32(7):905-910. [30] Zhang Lei,Liu Wenli,Men Dongpo,et al.Vitrinite reflectance distribution of coking coal and its additivity [J].Journal of Liaoning Technical University:Natural Science,2013,32(7):905-910. [31] 盛骤,谢式千,潘承毅.概率论与数理统计[M].4版.北京:高等教育出版社,2008:46-50. [32] 国家技术监督局.GB/T 15591—1995 商品煤反射率分布图的判别方法[S].北京:中国标准出版社,1995.
点击查看大图
计量
- 文章访问数: 702
- HTML全文浏览量: 75
- PDF下载量: 421
- 被引次数: 0